• Rail Trolleys
  • Rail Trolleys
  • Rail Trolleys
  • Rail Trolleys
  • Rail Trolleys

We design and manufacture
rail trolleys

The trolley platform allows you to install numerous additional devices on it – rolling racks, a bed, rotators, a driven and non-driven roller, a turntable, and much more.

 
load capacity, t
from 0.1 to 65
 
dimensions, mm
1000x1000 – 3000x10 000
 
speed, m/min
0.2 to 50

 

 

POWER CONNECTION METHODS

BATTERY

Modern production technologies for accumulator batteries allow to produce rail trolleys with a large range and a large load capacity. At that they are not as expensive as a spaceship..

 Advantage: They can travel infinitely long distances, while they are ecological and can be used in any general industrial premises.

Manufacturers give a warranty on the battery for up to 12 years or more than 1,500 cycles of charge.

 
. 
 
 
 

CABLE DRUM

The cable spring drum allows you to arrange a cable for a trolley with a track length of up to 100 m. The cable can be connected both in the beginning and in the middle, thus increasing the range of motion of the trolley twice at the lower cost of the drum. The trolley comes fully ready to use; it should only be connected to the electrical network.
 
 

THE LOOP METHOD

These are the most common and inexpensive trolleys in production. They require minimal preparation to start work – rail tracks and a connected network of electrical equipment. The cable is drawn as a loop behind the trolley along a steel stretched cable or laid along the rail track from an unwinding cable drum. In rare cases, when the length of the rail track is quite insignificant, the cable can freely lie in a special steel tray.
 
 

GENERATOR

A generator can be installed on the trolley, using any type of fuel:

  • Petrol
  • Diesel
  • Gas

The most common and affordable generator is a gasoline generator. In the cases, when the trolley enters the room, it is better to use a gas generator as the exhaust is more environmentally friendly

 
 

ROPE PULL

The trolley is driven by a steel closed cable. Electrical equipment and electrical power supply are completely absent on the trolley. The cable can be located on the floor surface, above and below, in a special channel. Trolleys with cable and chain traction are most often used in the production of concrete products, in shot blasting and molar chambers.
 
 

ADDITIONAL EQUIPMENT

OPERATOR CONSOLES

The remote control can be installed with- or without the wire, or using the control panel

SECURITY

Ultrasonic or laser sensors, a terminal switch, a sound and light motion signal

EXPLOSION-PROOF DESIGN

Special design of electrical equipment for hazardous areas

COLOR OF THE PAINT

We will paint it in any color according to RAL,
signal marking — according to GOST

 

OUR CLIENTS